|
COMPARISON
CHART
|
| |
Zero Flush
|
Waterless
|
Falcon/Sloan
|
| Cartridge |
No Cartridge. The patented removable drain insert,
together with permanent built in housing, creates the
trap. |
Cartridge Uses a pressure fit plastic cartridge (Eco-trap)
that requires adding Blue Seal every 1500 uses. |
Cartridge Uses an ABS cartridge that locks in place
using a bayonet clip system. |
| Trap Capacity |
Largest trap capacity in the industry.
Averages 15,000 uses before any maintenance is required.
The large housing allows for greater storage capacity
of the urine sediment resulting in higher usage thus increasing
the life cycle.
Total Trap Volume: 46 oz. |
Manufacturer suggests adding approximately
3 oz. of Blue Seal every 1500 uses. The cartridge needs
to be replaced after approximately 7,000 uses.
Total Trap Volume: 16 oz. |
Cartridge holds approximately 3 oz. of
sealant. Adding sealant between cartridge changes generally
is not necessary unless sealant has been lost.
Total Trap Volume: 18 oz. |
Maintenance Frequency
The frequency of changing the drain
insert or cartridge is NOT dependant on time. As the urinal
is used, urine sediment begins to fill the trap or cartridge.
When the trap/ cartridge is full, it needs to be changed.
The larger the trap/cartridge, the more uses you get from
your system. ZeroFlush has the largest trap in the industry.
SIZE MATTERS! |
Reduced Maintenance Time
and Costs. The trap housing is almost 3 times the size
of any other no water urinal. The urinal will give an
average of 15,000 uses before any maintenance is required,
this is when the drain insert should be changed. Using
the included specialized tool, pull up on the drain cover
and allow the contents in the housing to flow down the
waste line. Rinse the housing with a bucket of water.
Install a new insert and add one of the All-In-One Odor
Barrier and you’re done.
Engineered to minimize the loss of sealant.
The trap is designed to use 12 oz. of Odor Barrier Liquid
which will last for approximately 15,000 uses. No refill
is required between maintenance cycles. The system is
engineered to withstand a typical bucket of water poured
into the trap. |
Maintenance is continual as
Blue Seal must be added often to reduce odors. The cartridge
requires periodic changing. Manufacturer recommends tilting
the cartridge on its side to expel all free liquids (urine,
urine sediment, and Blue Seal) prior to discarding.
It is highly recommended by the manufacturer not to pour
a bucket of water into the urinal. The sealant may wash
away and could cause an odor issue. |
Suggested that the cartridge
must be replaced with a new one after approximately 7,000
uses. Manufacturer recommends tilting the cartridge on
its side to expel all free liquids (urine, urine sediment,
and Blue Seal) prior to discarding
It is highly recommended by the manufacturer not to pour
a bucket of water into the urinal. The sealant may wash
away and could cause an odor issue. |
| Sealant - 100% Natural, Biodegradable |
Yes |
No |
No |
| Green Option |
Yes. This option allows a customer to purchase only
the Odor Barrier, clean and reuse the insert and key,
and recycle the empty Odor Barrier bottle. |
No |
No |
